Evergreen Point Floating Bridge (1963)

Summary

The Evergreen Point Floating Bridge, officially the Governor Albert D. Rosellini Bridge, and commonly called the SR 520 Bridge or 520 Bridge, was a floating bridge in the U.S. state of Washington that carried State Route 520 across Lake Washington, connecting Medina with the Montlake/Union Bay district of Seattle.

Evergreen Point Floating Bridge (1963)
The bridge in 2009. Column-supported high-rises near the ends of the bridge are connected by a floating section.
Coordinates47°38′26″N 122°15′36″W / 47.6405°N 122.26°W / 47.6405; -122.26
Carries4 lanes of SR 520
CrossesLake Washington
LocaleSeattle to Medina (Washington, U.S.)
Official nameGovernor Albert D. Rosellini Bridge
Maintained byWashington State Department of Transportation
Characteristics
DesignPontoon bridge with movable midsections
Total length7,578 feet (2,310 m)
History
OpenedAugust 28, 1963
ClosedApril 22, 2016
Replaced byEvergreen Point Floating Bridge replacement (2016)
Location
Map

The bridge's total length was approximately 15,580 feet (4,750 m).[1] Its 7,578-foot (2,310 m)[2] floating section was the longest floating bridge in the world until April 11, 2016, when its replacement exceeded it by 130 feet (40 m).

The bridge was named for Evergreen Point, the westernmost of the three small Eastside peninsulas that SR 520 crosses. (The other two are Hunts Point and Yarrow Point.) In 1988, it was renamed for the state's 15th governor, Albert D. Rosellini, who had advocated its construction.[3]

Although there were plans to replace the bridge several years following its completion,[4] it was not until much later that investigations revealed the aging bridge to be in poor condition and unable to withstand the major hazards for which it was originally designed.[5] This finding may have accelerated plans to finally replace it. In response to these hazards and the need to expand the current infrastructure, construction on a replacement began in 2012; the new bridge opened in April 2016. The original bridge was closed to traffic on April 22, 2016.

History edit

 
Aerial view of the Evergreen Point Floating Bridge under construction, 1962. This shows the causeway extending from Foster Island in the Washington Park Arboretum roughly east to where Union Bay opens up into Lake Washington. Evergreen Point is across the lake.

The bridge was opened for commuter traffic on August 28, 1963, after three years of construction. It was built as a four-lane toll bridge to provide easy access from Seattle to Eastside communities such as Bellevue, Kirkland, and Redmond. The total cost of the bridge, in 1961 dollars, was $21 million (at least $127 million in 2011 dollars[6]).[7] To make up for this cost, commuters paid a 35-cent toll in each direction until 1979. The toll booths were then converted into bus stops.[citation needed]

The bridge affected many communities on the Eastside. Redmond's population saw a dramatic increase, jumping from less than 1,500 in 1960 to 11,000 in 1970.[8] It was the second floating bridge to cross Lake Washington; the first was the Lake Washington Floating Bridge, built in 1940 as part of U.S. Route 10, later part of Interstate 90, which at its construction was the largest floating structure ever built.[citation needed]

On August 28, 1988, the bridge was officially renamed for governor Albert D. Rosellini; the Washington State Transportation Commission approved of the renaming three days earlier ahead of the bridge's 25th anniversary celebration.[9] At the time, 109,000 vehicles used the bridge on an average day and 529 million vehicles were estimated to have crossed it since it opened.[10]

Drawspan opening edit

The bridge was built with a drawspan in the center that could open for boats too tall to go under the bridge.[11] The bridge opened by raising two 100-foot-long (30 m) steel grids about 7 feet (2.1 m) and moving an adjacent pontoon beneath them.[12]

In 1989, an electrical fault caused the drawspan to open during rush hour, causing one death and five injuries.[12] In 2000, a gravel barge struck the bridge.[13]

Replacement bridge edit

Just five years after the bridge opened, a study commissioned by the state legislature was completed to figure out how to provide for the great demand for cross-lake transportation. That study evaluated bridge and tunnel crossings north and south of the bridge.[14] Other plans considered in the late 1980s proposed the addition of rail transit or bus lanes to add capacity.[15] To prepare a case for the state legislature, the Trans-Lake Study was commissioned to study various alternatives.[16] The study brought together 47 representatives of public agencies, neighborhoods, businesses, and advocacy interests.[17]

In 1997, Myint Lwin, WSDOT's chief bridge engineer, said that even with repairs, the bridge could be expected to last only about twenty more years (until 2017).[18] The bridge needed to be closed to traffic in high winds, and even after a seismic retrofit in 1999, it was at risk of collapse during an earthquake. Due to the weight of various reinforcements over the years, the bridge deck ultimately sat about 1 foot (30 cm) lower over the water than it did originally.[citation needed]

Since the bridge was built in the early 1960s, prior to the implementation of modern earthquake standards, its hollow support structures would have likely failed during a major earthquake. Additionally, vibrations induced by storm surges and strong winds could have compromised the drawspan, anchor cables, and pontoons, subjecting them to structural failure.[19] Even for storms below the maximum threshold for failure to occur, Washington State Department of Transportation (WSDOT) still closed the floating bridge to traffic. The original bridge carried two lanes of traffic in each direction, but did not include emergency shoulders or pedestrian and bicycle crossings. This posed traffic problems since any obstruction caused by car breakdown, wreck or maintenance would result in traffic backups.[20]

In 2011, WSDOT broke ground on the replacement bridge.[21] On April 2, 2016, WSDOT held a grand opening ceremony, allowing the public to explore the top deck of the new bridge on the westbound side.[22] The replacement bridge opened to westbound traffic on April 11, 2016, and opened to eastbound traffic on April 25, 2016.[23] The old bridge was permanently closed at 23:00 PDT on April 22, 2016, with demolition completed by the end of 2016.[citation needed] The bridge was removed by spring 2017.[24]

Construction edit

 
Replacement bridge, to the north of the Rosellini Bridge, under construction in May 2015
 
Photo of the south side of the bridge in 2015, with construction visible in the background.
 
New Evergreen Point Floating Bridge has been in use since April 2, 2016.

The cost of all improvements to SR-520 between I-5 and I-405, including the new bridge, is forecast to be $4.65 billion.[25]

The first of 21 longitudinal pontoons were positioned on August 11, 2012. Each pontoon is 360 feet (110 m) long and 75 feet (23 m) wide.[26] The pontoons were constructed in Aberdeen by Kiewit Construction. Pontoon construction was plagued by errors and shoddy construction. Reports included workers installing incorrectly sized rebar, installing it in the wrong location, and even having it missing altogether. Workers also poured concrete in weather that was too wet or too cold. Several of the new pontoons have had problems with cracking, which has been blamed on Kiewit's poor work. An independent auditor stated that there had been a long-running pattern of poor-quality work and that WSDOT failed to force Kiewit to take corrective actions. An inspector for the construction called it a disaster waiting to happen, adding "I won't drive across that bridge when they have it built."[27]

By the end of February 2015, enough of the new bridge was in place to block tall ships that used to pass through a drawspan in the Rosellini Bridge.[28] In early July 2015, the westernmost floating pontoon was moved to make room for the installation of the west end of the bridge; on July 8, 2015, all longitudinal pontoons for the new bridge were in place.[29]

Tolling edit

When the bridge opened in 1963, a 35 cent toll was collected to pay off a construction bond. The sole toll plaza was located at the east end of the bridge in Medina and had nine booths.[30] The state government offered discounts to commuters using a ticket book, as well as carpools of two or more people.[31][32] The toll was retired on June 22, 1979, after the $35 million bond had been paid off 20 years ahead of schedule.[33] More than 213 million vehicles had used the toll bridge and generated $59.6 million in revenue.[34]

Tolls were reinstated in December 2011 to fund the original bridge's replacement. Within the first year, traffic levels declined by 30 percent and tolls generated $50 million in gross revenue.[35]

To fund the new bridge, in May 2009, Governor Christine Gregoire signed ESHB 2211, which authorized tolling on the SR 520 bridge beginning in 2010.[36] Tolling actually began on December 29, 2011, and has assisted WSDOT in funding the project.[25] The State Transportation Commission has proposed a toll of US$3.59 each way during peak periods. The proposed rates during other hours were to range from $0 to $2.87.[37]

All tolling was done automatically with no tollbooths. Tolling for people without "Good to Go" passes is done by license plates.[25] Toll readers were located on gantries at the east highrise,[38] but additional gantries on the east mainland were added to facilitate tolling on the new bridge once opened.

Tim Eyman promoted Initiative 1125, which among other measures, would have banned the time-of-day tolling proposed for the bridge, required funding to be used on the road that collected the toll, and required tolls to be set by elected officials.[39] The initiative was defeated by Washington voters.[40]

See also edit

References edit

  1. ^ USGS map
  2. ^ WSDOT - SR 520 Bridge Facts Archived April 21, 2015, at the Wayback Machine. Washington State Department of Transportation. Accessed May 22, 2011.
  3. ^ Lange, Greg (January 14, 1999). "Evergreen Point Floating Bridge opens on August 28, 1963". HistoryLink.
  4. ^ "Highway Department: Commission Bars Traffic Study". The Seattle Times. December 16, 1969. p. E6.
  5. ^ "SR 520 Floating Bridge Replacement". GeoEngineers. Retrieved March 17, 2017.
  6. ^ Williamson, Samuel H. (April 2012). "Seven Ways to Compute the Relative Value of a U.S. Dollar Amount – 1774 to Present". MeasuringWorth. Using the "Project" costs.
  7. ^ "SR 520 Bridge Replacement and HOV Project - Historic Archive Gallery". Archived from the original on October 5, 2011.
  8. ^ City of Redmond, "Redmond Comprehensive Plan"., 2005
  9. ^ Gough, William (August 26, 1988). "New name for span: Gov. Albert D. Rosellini Evergreen Point Bridge". The Seattle Times. p. B1.
  10. ^ Glover, Darrell (August 29, 1988). "Rosellini bridge now 25—and still disputes swirl". Seattle Post-Intelligencer. p. C16.
  11. ^ "SR 520 Drawspan Opening". YouTube. Retrieved November 2, 2016.
  12. ^ a b "Woman Killed as Seattle Span Opens Accidentally". New York Times. December 24, 1989. Retrieved November 2, 2016.
  13. ^ Pryne, Eric (August 1, 2000). "Wayward tugboat missed turn before barge smashed bridge". Seattle Times. Retrieved October 20, 2021.
  14. ^ Tudor Engineering Company for Washington State Highway Commission Department of Highways. Legislative Reconnaissance and Feasibility Report "Lake Washington Bridge Crossings, Parallel Evergreen Point Bridge, North Lake Bridge. December 1968.
  15. ^ Gough, William (August 28, 1988). "A bridge too small". The Seattle Times. p. A1.
  16. ^ Whitely, Peyton (May 28, 1998). "Group seeks ways to ease traffic congestion across lake". Seattle Times. Archived from the original on April 24, 1999.
  17. ^ Trans-Lake Study, June 1999, archived from the original on March 3, 2004
  18. ^ Whitely, Peyton. "New bridge first faces political, fiscal tests." "Seattle Times". February 19, 1997.
  19. ^ "The Longest Floating Bridge: SR 520". American Infrastructure. Retrieved March 17, 2017.
  20. ^ "Ten Years of SR 520 Bridge Project". Shannon & Wilson. Archived from the original on March 18, 2017. Retrieved March 17, 2017.
  21. ^ "SR 520 Pontoon Progress Updates". WSDOT. Archived from the original on January 19, 2015. Retrieved January 16, 2015.
  22. ^ "Old 520 Bridge closed this weekend during new bridge celebration". MYNorthwest.com. April 2, 2016. Retrieved April 3, 2016.
  23. ^ "SR 520 Bridge Replacement and HOV Program" (PDF). WSDOT. Archived from the original (PDF) on April 17, 2016. Retrieved April 3, 2016.
  24. ^ "SR 520 Floating Bridge and Landings Project" (PDF). Washington Department of Transportation. April 2017. p. 8. Retrieved October 20, 2021.
  25. ^ a b c "SR 520 Program - Costs, Funding and Tolling". WSDOT. Retrieved June 6, 2012.
  26. ^ Lindblom, Mike (August 10, 2012). "Putting together the 520 bridge". The Seattle Times. Retrieved August 10, 2012.
  27. ^ Tracy Vedder (November 20, 2012). "Former inspector: New 520 Bridge 'a disaster waiting to happen'". Seattle Post-Intelligencer. Retrieved November 26, 2012.
  28. ^ Mike Lindblom (February 15, 2015), "520 bridge drawspan openings are coming to a close", The Seattle Times
  29. ^ Thompson, Roger (July 8, 2015). "Get in line: Largest pontoons for new SR 520 floating bridge all in final position on Lake Washington" (Press release). Washington State Department of Transportation. Retrieved July 9, 2015.
  30. ^ Hahn, Jon (June 17, 1979). "Evergreen Has Taken Its Toll". Seattle Post-Intelligencer. p. A1.
  31. ^ Dougherty, Phil (November 3, 2015). "Six toll takers at the Evergreen Point Floating Bridge are arrested for embezzlement of toll proceeds on June 18, 1975". HistoryLink. Retrieved May 5, 2022.
  32. ^ Sanger, S. L. (July 16, 1975). "'Bridge Toll, Traffic Patterns Work Fine'". Seattle Post-Intelligencer. p. A5.
  33. ^ Duncan, Don (June 23, 1979). "Bridging a generation". The Seattle Times. p. A3.
  34. ^ Wilson, Marshall (June 20, 1979). "But what comes next in oft-tolled tale?". The Seattle Times. p. H1.
  35. ^ "Tolling of SR-520 bridge passes one-year mark". Mercer Island Reporter. December 27, 2012. Retrieved May 5, 2022.
  36. ^ "ESRB 2211".
  37. ^ Comments sought on proposed SR 520 toll rates. KPBJ.com (December 5, 2010). Retrieved on 2011-08-29.
  38. ^ "SR 520 Tolling Frequently Asked Questions". WSDOT. Retrieved August 29, 2011.
  39. ^ Michael Ennis (September 2011). "Citizens' Guide to Initiative 1125". Washington Policy Center. Retrieved January 3, 2011.
  40. ^ "Gregoire, Reed Certify 2011 Election Returns". Mason County Daily News. December 7, 2011. Archived from the original on April 21, 2012. Retrieved January 3, 2011.

External links edit

  • Historic American Engineering Record (HAER) No. WA-201, "Evergreen Point Floating Bridge, On SR 520, Seattle, King County, WA", 86 photos, 44 data pages, 6 photo caption pages
  • Evergreen Point Floating Bridge at Structurae  
  • Bridge camera (includes some weather data)
  • Department of Transportation photo gallery
  • Video of a daytime drawspan opening, with commentary from a WSDOT engineer on YouTube