M202 FLASH

Summary

The M202 FLASH ("Flame Assault Shoulder")[3] is an American rocket launcher manufactured by Northrop Corporation, designed to replace the World War II–vintage flamethrowers (such as the M1 and the M2) that remained the military's standard incendiary devices well into the 1980s. The XM202 prototype launcher was tested in the Vietnam War, as part of the XM191 system.[4]

Launcher, Rocket, 66mm, 4-Tube, M202
TypeMultishot incendiary rocket launcher
Place of originUnited States
Service history
Used bySee Operators
Production history
Designedc. 1970
ManufacturerNorthrop Corporation, Electro-Mechanical Division[1]
Produced1978
VariantsM202, M202A1
Specifications
Mass11.5 lb (5.22 kg) empty
26.6 lb (12.07 kg) loaded
Length27 in (686 mm) closed
34.75 in (883 mm) extended

CartridgeM235 Incendiary TPA
Caliber2.6 in (66 mm)
ActionSingle shot (each rocket has its own firing pin)
Muzzle velocity375 ft/s (114 m/s)
Effective firing range22 yd (20 m) minimum
Maximum firing range820 yd (750 m) (area target)
219 yd (200 m) (point target)
Feed system4 rocket clip[2]
SightsReflex

History edit

The United States Army issued M202s as needed, with each rifle company's headquarters being authorized a single launcher, generally issued as one per rifle platoon. While vastly more lightweight than the M2 flamethrower it replaced, the weapon was still bulky to use and the ammunition suffered from reliability problems. As a result, the weapon had mostly been relegated to storage by the mid-1980s, even though it nominally remains a part of the U.S. Army arsenal.

In USMC service, the M202 was issued to dedicated teams of 0351 Assaultman at the battalion level. The Weapons Platoon's assault section contained three squads, each with a launcher team.[5] With the introduction of the SMAW in the mid 1980s, the M202 was phased out and replaced by SMAW launchers.

The M202A1 has been among weapons listed on the inventory of U.S. units in the War in Afghanistan.[6]

 
The XM191 MPFW

Design edit

The M202A1 features four tubes that can load 66 mm incendiary rockets.[7] The M-74 rockets are equipped with M235 warheads, containing approximately 1.34 pounds (610 g) of an incendiary agent. The substance, often mistaken for napalm[citation needed], is in fact TPA (thickened pyrophoric agent).

 
Opened M202.

TPA is triethylaluminum (TEA) thickened with polyisobutylene, in the presence of n-hexane, preventing spontaneous combustion after the warhead rupture. TEA, an organometallic compound, is pyrophoric and burns spontaneously at temperatures of 1600 °C (2912 °F) when exposed to air. It burns "white hot" because of the aluminum, much hotter than gasoline or napalm. The light and heat emission is very intense and can produce skin burns from some (close) distance without direct contact with the flame, by thermal radiation alone. A crowd control agent round using CS gas, the XM96, was trialed, but never entered service.[citation needed]

 
Component containing the M-74

The weapon is meant to be fired from the right shoulder, and can be fired from either a standing, crouching, or prone position. It is loaded with a clip which holds a set of four rockets together, which is inserted into the rear of the launcher and can be pushed past the launching position to enable the launcher to be carried while loaded more easily.

 
Marines prepare to test-fire an M202 in South Vietnam, 1970

The M202A1 was rated as having a 50% chance of hit against the following targets at the noted ranges, assuming all four rockets were fired at the same time:

  • Bunker aperture: 50 meters
  • Window: 125 meters
  • Weapons position or stationary vehicle: 200 meters
  • Squad-sized troop formation: 500 meters

Operators edit

 
Map with M202 operators in blue

See also edit

Notes edit

  1. ^ Authorization for Military Procurement, Research, and Development, Fiscal Year 1971, and Reserve Strength. U.S. Govt. Print. Off. 1970.
  2. ^ https://books.google.com/books?id=4zIuAAAAYAAJ . US Army Manual, April 1978
  3. ^ https://nationalinterest.org/blog/reboot/arnold-loved-it-us-militarys-last-flamethrower-flash-180721
  4. ^ "DTIC AD0868942: XM191 Multishot Portable Flame Weapon - ENSURE 263". March 1970.
  5. ^ "Marine Infantry Battalion FMFM 6-3" (PDF). United States Department of the Navy. 1978.
  6. ^ Hambling, David (May 15, 2009). "U.S. Denies Incendiary Weapon Use in Afghanistan". Wired.com. Accessed 27 May 2010.
  7. ^ https://modernfirearms.net/en/grenade-launchers/u-s-a-grenade-launchers/m202-flash-eng/
  8. ^ https://sofrep.com/news/m202-flash-rocket-launcher/

References edit

  • US Army Manual, TC 23-2, 66 mm rocket launcher M202A1, April 1978
  • TM 3-1055-456-12 M202A1 Operator's Manual.
  • U.S. patent 4,230,509: Pyrophoric flame composition

External links edit

  • M202A1 Flame Assault Shoulder Weapon (Flash) at Gary's U.S. Infantry Weapons Reference Guide]
  • 66 mm Incendiary Rocket M74 at Designation Systems
  • TC 23-2 66 mm Rocket Launcher M202A1—US Army Manual, April 1978
  • M202 FLASH on Youtube
  • This Rocket Launcher Was the U.S. Army’s Last Flamethrower War is Boring