TWA Flight 841 (1979)

Summary

TWA Flight 841 was a scheduled passenger flight from John F. Kennedy International Airport in New York City, en route to Minneapolis-Saint Paul International Airport in Minneapolis, Minnesota. On April 4, 1979, at or around 9:48 p.m. Eastern Standard Time (01:48 UTC), while flying over Saginaw, Michigan, the Boeing 727-31 airliner began a sharp, uncommanded roll to the right, and subsequently went into a spiral dive. The pilots were able to regain control of the aircraft and made a successful emergency landing at Detroit Metropolitan Airport.

TWA Flight 841
N840TW, the aircraft involved, seen at St. Louis Lambert International Airport, on 1 August 1984, five years after the incident.
Accident
DateApril 4, 1979
SummaryUncontrolled descent

Cause disputed:

• Leading edge slat failure (NTSB)

• Yaw damper induced lower rudder hardover (ALPA)
SiteOver Saginaw, Michigan, United States
Aircraft
Aircraft typeBoeing 727-31
OperatorTrans World Airlines
IATA flight No.TW841
ICAO flight No.TWA841
Call signTWA 841
RegistrationN840TW
Flight originJohn F. Kennedy International Airport,
New York City, U.S.
DestinationMinneapolis-Saint Paul International Airport,
Minneapolis, U.S.
Occupants89
Passengers82
Crew7
Fatalities0
Injuries8
Survivors89

Incident edit

At 8:25 p.m. EST, TWA Flight 841 departed JFK International after a 45-minute delay due to traffic congestion and reached its initial cruising altitude of 35,000 feet at 8:54 p.m. Due to a 100-knot headwind, the pilots requested to climb to 39,000 feet at 9:25 p.m., which was granted. At 9:49 p.m., after traveling nearly 540 miles (870 km),[1] while cruising at 39,000 feet (12,000 m) near the city of Saginaw, Michigan, Captain Harvey "Hoot" Gibson (44),[2] said the aircraft was operating with the autopilot on "Altitude Hold" mode when he felt a high frequency vibration in the balls of his feet, followed by a buzzing sound and a light buffeting of the airframe. He saw the plane's nose yaw to the right, pause and then yaw right again. He looked at his instruments and saw the plane banking right with the autopilot moving the control wheel to the left to level the wings. This had no effect so Gibson disconnected the autopilot and applied full left aileron which had no effect. He got on the rudder pedals to apply full left rudder. He would state that as he did so he felt something didn't feel right with the rudder but didn't know what it was. Captain Gibson's inputs had no effect as the plane very quickly began a steep roll to the right.[3]: 2  Gibson shouted "Get em' up!" referring to the co-pilot to deploy the speed brakes, but the co-pilot didn't understand what the Captain meant so Gibson deployed them. Despite the best efforts of the flight crew, the aircraft spiraled out of control; Gibson shouted, "We're going over!". Flight 841 dove about 34,000 feet (10,000 m) in just 63 seconds.[3]: 2  During the course of the dive, the plane rolled through 360 degrees twice and exceeded the Mach limit for the 727 airframe. Captain Gibson got so desperate to save the plane that he began moving his control column from all the way left to all the way right, then all the way forward and all the way back, full left rudder, then full right rudder, and retracted and extended the speedbrakes, but his efforts were fruitless.

At about 15,000 feet (4,600 m) the pilots extended the landing gear in an attempt to slow the aircraft. A few seconds after extending the gear, Gibson managed to regain control and pulled the 727 out of its dive at about 5,000 feet (1,500 m).[4][5] The plane suffered substantial structural damage with the System A hydraulics ruptured as a result of the right main landing gear overextending and the Flight Engineer reported they had a fail flag for the lower rudder yaw damper but made an emergency landing at Detroit Metropolitan Airport in Michigan at 10:31 p.m. EST without further trouble. After landing and shutting the engines down the pilots turned on the Auxiliary Power Unit (APU) as a mechanic plugged into an intercom to talk to the pilots and reported fuel was leaking from the left side. All 89 people deplaned via the aft airstair and no fatalities occurred among the 82 passengers and 7 crew members. Eight passengers reported minor injuries related to high g-forces.[3]

Investigation edit

The National Transportation Safety Board (NTSB) investigated the accident, conducting what was at the time the lengthiest accident investigation in NTSB history.[6] In its final report, published in June 1981, the NTSB concluded the probable cause of the accident was a mechanical failure of a leading-edge slat under inappropriate manipulation and the captain's untimely action.[3]: 1 

Among the damage discovered after the accident, investigators found the #7 slat missing from the leading edge of the right wing. NTSB investigators requested the aircraft manufacturer, Boeing, inspect the remainder of the slat assembly, including a portion of the slat actuator cylinder (the motor that moves the slat and holds it in position). Boeing determined that the #7 slat had failed because the slats had been extended while the aircraft was flying at cruising speed. They also determined that it was "impossible" for the flaps to extend without manipulating the controls.[7]

After eliminating all individual and combined sources of mechanical failure, the NTSB ruled that the extension of the slats was due to the flight crew manipulating the flap/slat controls in an inappropriate manner.[3]: 2 [8] Investigators believed that 727 pilots (in general, and this flight specifically) were setting the trailing edge flaps to two degrees during high altitude cruise, while at the same time pulling the circuit breaker for the slats so that they would not activate. This configuration was rumored to result in increased lift with no increase in drag, thus allowing more speed, higher elevation, or decreased fuel consumption. Flaps and slats were intended to only be deployed at low speeds during take-off or landing.[3]

The crew, Capt. Harvey G. "Hoot" Gibson (1934-2015),[9] First Officer J. Scott Kennedy (1939-2017),[10] and Flight Engineer Gary N. Banks (born 1942), denied that their actions had been the cause of the flaps' extension:

At no time prior to the incident did I take any action within the cockpit either intentionally or inadvertently, that would have caused the extension of the leading edge slats or trailing edge flaps. Nor did I observe any other crew member take any action within the cockpit, either intentional or inadvertent, which would have caused the extension.

— Capt. Gibson[11][12]

The crew suggested instead that an actuator on the #7 slat had failed, causing its inadvertent deployment. The NTSB rejected this as improbable and attributed the extension of the flaps to the deliberate actions of the crew. The crew claimed that such failures had happened on other 727s prior and subsequent to this incident.[13] The NTSB report noted that between 1970 and 1973, seven separate cases involving a single leading edge slat extension and separation were reported, but none of these reports indicated whether or not the slat extension was due to flight crew involvement.[3]: 18  Records after 1974 did include this information, and (other than Flight 174) only two slat extension problems were reported between 1974 and the close of the NTSB's investigation in 1981, one of which was inadvertently caused by the flight crew.[3]: 24  However, in none of these previous cases did the plane become uncontrollable.

The flight crew testified that they had not engaged the flaps, and the NTSB concluded that "if the flightcrew's recollections are accurate," the slat extension must have been caused by a mechanical failure or defect.[3]: 24  However, the NTSB ultimately concluded that the flight crew was probably attempting to use 2º of flaps at cruising speed:

While cruising at Mach 0.816 and 39,000 feet pressure altitude and with the autopilot controlling the aircraft, an attempt was made to extend 2º of trailing edge flaps independently of the leading edge slats, probably in an effort to improve aircraft performance[3]: 32 

When retraction of the flaps was ordered, the Number 7 leading edge slat failed to retract, causing the uncommanded roll to the right.

The Safety Board determines that the probable cause of this accident was the isolation of the No. 7 leading edge slat in the fully or partially extended position after an extension of the Nos. 2, 3, 6 and 7 leading edge slats and the subsequent retraction of the Nos. 2, 3, and 6 slats, and the captain's untimely flight control inputs to counter the roll resulting from the slat asymmetry. Contributing to the cause was a preexisting misalignment of the No. 7 slat which, when combined with the cruise condition airloads, precluded retraction of that slat. After eliminating all probable individual or combined mechanical failures, or malfunctions which could lead to slat extension, the Safety Board determined that the extension of the slats was the result of the flightcrew's manipulation of the flap/slat controls. Contributing to the captain's untimely use of the flight controls was distraction due probably to his efforts to rectify the source of the control problem.[3]: 1 

Gibson and the Air Line Pilots Association (ALPA) appealed against the NTSB's findings, first to the NTSB itself in 1983, 1990, 1991, 1992, and 1995 and then to the U.S. Ninth Circuit Court of Appeals.[6][14] Both petitions were rejected: the former for lack of new evidence, and the latter for lack of jurisdiction due to the NTSB's "unreviewable discretion".

The aircraft was repaired and returned to service in May 1979.

Cockpit voice recorder edit

The aircraft was equipped with a Fairchild Industries Model A-100 cockpit voice recorder (CVR). However, 21 minutes of the 30-minute tape were blank.[3]: 6  Tests of the CVR in the aircraft revealed no discrepancies in the CVR's electrical and recording systems (the NTSB was erroneously told by someone at TWA that there were no faults with the CVR when no tests were ever carried out).[3]: 6  The CVR tape can be erased by means of the bulk-erase feature on the CVR control panel located in the cockpit. This feature can be activated only after the aircraft is on the ground with its parking brake engaged.[3]: 6  In 1979 it was essentially a standard procedure at the end of every flight to erase the CVR if the flight was routine for privacy reasons.[15] In a deposition taken by the Safety Board, the captain stated that he usually activates the bulk-erase feature on the CVR at the conclusion of each flight to preclude inappropriate use of recorded conversations. However, in this instance, he could not recall having done so.[3]: 6  The NTSB made the following statement in the accident report:

We believe the captain's erasure of the CVR is a factor we cannot ignore and cannot sanction. Although we recognize that habits can cause actions not desired or intended by the actor, we have difficulty accepting the fact that the captain's putative habit of routinely erasing the CVR after each flight was not restrainable after a flight in which disaster was only narrowly averted. Our skepticism persists even though the CVR would not have contained any contemporaneous information about the events that immediately preceded the loss of control because we believe it probable that the 25 minutes or more of recording which preceded the landing at Detroit could have provided clues about causal factors and might have served to refresh the flightcrew's memories about the whole matter.[3]: 33 

Criticism of investigation edit

In the book Emergency: Crisis In the Cockpit,[16] Stanley Stewart, a professional pilot, raised questions about the NTSB findings:

  • Stewart suggests that the crew would not have been able to erase the CVR as the aircraft had to be completely shut down and on the ground. According to Stewart, the damage should have meant that the computers did not recognize the aircraft in a fully landed state (page 217).
  • He also pointed out that a CVR technical expert had been interviewed for 'Popular Mechanics' and stated that the slow transfer of electrical power from engine power to the APU after it was turned on likely caused the erasure of the CVR (page 217).
  • He suggests that there were other incidents of 727-200s with uncommanded slat extensions in the years prior to and after the accident (page 224).
  • The flight crew knew the aircraft was potentially unstable at 39,000 ft. Stewart believes it would be unlikely they would "fool around" with the controls and risk the stability of the aircraft (page 221).

Trans World Airlines and ALPA investigators contend that once the NTSB investigators discovered that 21 minutes of the Cockpit Voice Recorder were blank, instead inspecting it for any deficiencies or ever considering the possibility that it wasn't working properly, they quickly concluded the pilots had erased it and developed their own preconceived notion that the pilots had caused the upset instead of letting the evidence lead them to a conclusion. They conducted the investigation with the flight crew's sworn testimonies discounted and elected not to further question them about the events leading up to the upset. The NTSB's conclusions were based on their biased opinion on what they believed had happened, even though it bore no resemblance to the flight crew or passengers' version of events. [17]

In 1990, ALPA sent a petition to the NTSB to reconsider their findings after discovering the investigators made serious investigative errors during the investigation. ALPA concluded the No. 7 slat did not cause the upset and instead extended as a result of the upset. They stated evidence best supported that while cruising at 39,000 feet, the bolt to the outboard right aileron on TWA flight 841 fractured, causing the aileron to flutter and create the high frequency vibration Captain Gibson reported. As the aileron floated up, the plane banked to the right and turned off its heading, the autopilot tried to correct for this by moving the control wheel left. Once the control wheel turned more than 10°, the spoilers on the left wing deployed to aid in roll control, creating the buzzing sound. With the plane turning right and the autopilot commanding a left turn, the 727 was in a cross-controlled position. The yaw damper rate gyro and or coupler sensed discrepant rudder inputs which resulted in the lower rudder going into the hardover position, causing the plane to yaw severely right. In this condition the left wing produced more lift as a result. A large sideslip angle on sweptback planes like the 727 produces a large rolling moment. Although Gibson disconnected the autopilot and applied opposite aileron and upper rudder, with the lower rudder in the hardover position and limited roll control due to the right outboard aileron free-floating, his control inputs were insufficient to prevent TWA 841 from going into an uncontrollable spiral dive. When the crew lowered the landing gear, the over extension of the right main landing gear ruptured System A hydraulics which centered the lower rudder and allowed the pilots to recover from the dive. Analysis of the No. 7 slat by the NTSB showed a lack of wear, it was misaligned, and didn't lock into its locking mechanism, meaning that it was held in place only by hydraulic pressure and aerodynamic forces. With the loss of hydraulics, the slat extended at 8,000 feet and quickly ripped off. The other slats stayed retracted because they locked into their locking mechanisms.[18]

Professional pilot and author, Emilio Corsetti III, stated in his book Scapegoat: A Flight Crew's Journey From Heroes to Villains to Redemption,[19] that the Boeing engineers and NTSB investigators massaged the data to make it match their version of events, not the flight crew's version of events (page 192); and "had the NTSB not let the supposed erasure of the CVR implant a bias on the investigation, they might have considered possibilities other than crew involvement. They might have talked to the crew in greater detail and would have learned that the plane yawed before the upset" (page 384).

In media edit

This incident was the subject of a 44-minute CBS News Special titled "The Plane That Fell From The Sky". The special won a Peabody Award in 1983.[20]

The incident was featured on season 22 of the Canadian documentary series Mayday, in the episode titled "Terror over Michigan".[21]

See also edit

References edit

  1. ^ "Distance Between Cities Places On Map Distance Calculator". Retrieved February 6, 2017.
  2. ^ Corsetti, Emilio (February 2015). "Hoot Gibson Remembered". Scapegoat: A Flight Crew’s Journey from Heroes to Villains to Redemption. Retrieved September 20, 2022.
  3. ^ a b c d e f g h i j k l m n o p Aircraft Accident Report - Trans World Airlines, Inc., Boeing 727-31, N840TW, Near Saginaw, Michigan April 4, 1979 (PDF). National Transportation Safety Board. June 9, 1981. - Copy at Embry-Riddle Aeronautical University.
  4. ^ Peterson, Iver. "Plane Passengers Prayed But Expected to Be Killed." The New York Times (April 7, 1979), 6.
  5. ^ The Post-Standard (Syracuse, New York), June 10, 1981, page 11
  6. ^ a b "11 Years After Plane Took A Dive, Pilot Tries To Clear His Reputation". Chicago Tribune. October 14, 1990. Retrieved February 6, 2017.
  7. ^ otosflashymoon (September 17, 2012). "The Plane That Fell From The Sky (Full Version) TWA 841". Archived from the original on December 15, 2021. Retrieved February 6, 2017 – via YouTube.
  8. ^ Witkin, Richard. "Safety Board Hints Crew Errors May Have Led to Jet Dive Over Michigan." The New York Times (January 18, 1980), A10.
  9. ^ "Hoot Gibson remembered". February 2015.
  10. ^ "The passing of Scott Kennedy". October 26, 2017.
  11. ^ Witkin, Richard. "Crew Will Testify Today On Near-Fatal Jet Plunge." The New York Times (Apr 12, 1979), B10.
  12. ^ Lindsey, Robert. "Pilot Says Extending Landing Gear Was Near Last Resort to Stop Dive." The New York Times (Apr 13, 1979), A16.
  13. ^ Boeing Operations Manual Bulletin, OMB 75-7, March 10, 1976; Subject: "Leading Edge Slat Actuator Lock Rings"; outlined specific conditions which had previously resulted in a Leading Edge Slat being pulled from the Retracted position (Mach > .8M, with failure of "A" System Hydraulic pressure to the slat actuator, with SpeedBrakes/Spoilers Extended).
  14. ^ "FindLaw's United States Ninth Circuit case and opinions". Retrieved February 6, 2017.
  15. ^ "A little background on the CVR". February 4, 2013.
  16. ^ Stewart, Stanley (January 1, 1991). Emergency! Crisis In The Cockpit. ISBN 978-0830634996.
  17. ^ "The story of the CVR and the man with blinders". April 26, 2013.
  18. ^ "Petition for Reconsideration of Probable Cause".
  19. ^ Corsetti III, Emilio (August 1, 2016). Scapegoat: A Flight Crew's Journey From Heroes to Villains to Redemption. ISBN 978-0997242102.
  20. ^ "The Plane That Fell From the Sky". Retrieved February 6, 2017.
  21. ^ "TWA Flight 841 (1979) on IMDb". IMDb.

External links edit

  • Accident description at the Aviation Safety Network
  • NTSB Synopsis
  • U.S. Ninth Circuit Court of Appeals, GIBSON v NTSB (appeal dismissed--lack of jurisdiction)